12.24.2020
Table of Contents
- In the passenger compartment
- Type 1
- Type 2
- In the engine compartment
- Type 1
- Type 2
Ford Explorer is a midsize crossover. Produced from 1990 to the present in five generations. In this article, we will show a description of the 5th generation Ford Explorer fuse and relay blocks, produced in 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018, 2019, 2020. During this period, the Ford Explorer was updated 2 times.
The manufacturer reserves the right to make changes to the technical characteristics, specifications and equipment of any model, therefore there is no one general description for all Ford Explorer cars. Check the purpose of the elements with your technical documentation, and in case of difficulty, contact your dealer.
In the passenger compartment
Fuse box located under the dashboard on the driver's side and is covered by a protective cover.
The current scheme will also be applied on it.
Type 1
Cars manufactured up to 2015.
General view.
Diagram | |
---|---|
№ | Description |
1 | 30A Driver's side front window lifter with one-push function |
2 | 15A Not used (spare) |
3 | 30A One-push front passenger side window regulator |
4 | 10A Interior lights on request (roof console, second row, luggage compartment), glove box lamp, second and third row seat folding lights, sun visors lights |
5 | 20A Amplifier |
6 | 5A Reserve |
7 | 7.5A Power supply of the logic module for storing the seat position |
8 | 10A Reserve |
9 | 10A 4 '' radio display (SYNC), power liftgate logic module, electronic trim panel |
10 | 10A Relay for operating mode / power supply mode for auxiliary equipment (wipers, rear window washer), rain sensor |
11 | 10A Instrument panel, projected display on the windshield |
12 | 15A Step lamps (roof console, second row, luggage compartment), underside lamps, console compartment LED, backlight |
13 | 15A Right turn signal lamps, right turn signal / trailer stop lamps (TT) |
14 | 15A Left turn signal lamps, left turn signal / trailer brake lamps (TT) |
15 | 15A Reversing lights, brake lights, additional brake light |
16 | 10A Low beam headlamps (right) |
17 | 10A Low beam headlights (left) |
18 | 10A Keypad Illumination, Brake Pedal Release Interlock (BSI), Start Button Operation Indicator, PATS, Powertrain Control Module (PCM) Start, Power Supply for Rear Seat Height Adjustment |
19 | 20A Seat memory power supply |
20 | 20A Locks |
21 | 10A Intelligent Access (IA), Keypad |
22 | 20A Horn relay |
23 | 15A Steering Wheel Control Module, Intelligent Access (IA), Headlight Switch |
24 | 15A Data connector, steering wheel control module |
25 | 15A Removing the luggage compartment door lock |
26 | 5A RF module |
27 | 20A Intelligent Access Module |
28 | 15A Ignition lock, start by button |
29 | 20A Radio, Global Positioning System (GPS) Module |
30 | 15A Front side lights |
31 | 5A Trailer brake controller |
32 | 15A 110V AC Power Socket, Power Folding Mirror, Power Mirrors, One-Push Front Power Windows, Door Lock Lights, Memory Switch Lights |
33 | 10A Sensor for the recognition of the presence of the driver and passenger |
34 | 10A Blind Spot Monitor, Rear View Camera, Rear Vehicle Monitoring System |
35 | 5A Projected windscreen display, climate control humidity sensor, terrain control system, hill descent assist switch, headlight switch sensor |
36 | 10A Steering wheel heating |
37 | 10A Control module for restraining system of airbags and seat belts |
38 | 10A Auto-dimming rearview mirror, power sunroof |
39 | 15A High beam blinds |
40 | 10A Rear parking lights, license plate lights, trailer parking lights |
41 | 7.5A Overdrive Cancellation, Towing / Cargo Carrying Mode |
42 | 5A Reserve |
43 | 10A Reserve |
44 | 10A Reserve |
45 | 5A Reserve |
46 | 10A Climate control module |
47 | 15A Fog lights, supply of direction indicators in the right and left mirrors |
48 | 30A Circuit breaker: Power rear windows, power passenger window, one-push down (driver's side only), driver's door power window switch |
49 | Accessory Power Off Delay Relay (Body Control Module) |
Type 2
Cars manufactured from 2015.
General view.
Diagram | |
---|---|
№ | Designation |
1 | 10A Interior lamps, Battery Discharge Prevention System |
2 | 7.5A Seat control switch with memory position (with electric drive) |
3 | 20A Driver door unlock relay |
4 | 5A Optional electronic brake controller |
5 | 20A Heated rear seat module |
b | Reserve |
7 | Reserve |
8 | Reserve |
9 | Reserve |
10 | 5A Securicode Keyless Entry Keypad, Automatic Rising Door |
11 | 5A Rear climate control module |
12 | 7.5А Front climate control system module |
13 | 7.5A Instrument panel Intelligent data link, Steering column control module |
14 | Reserve |
15 | 10A Power Intelligent Data Link Connector, Ceiling Display |
16 | Reserve |
17 | 5A Trim panel with electronics |
18 | 5A Car start button, Ignition lock (switch) Key lock |
19 | 7.5A Gearbox control switch (towing function) |
20 | Reserve |
21 | 5A Terrain Control Switch, Ceiling Display, Humidity Sensor |
22 | 5A Driver / passenger classification sensor |
23 | 10A Auxiliary Power Delay Power Circuit, Power Windows, Sunroof, Folding Mirror Relay, DC Inverter, Window / Sunroof Switch Illumination |
24 | 20A Centralized blocking relay |
25 | 30A Smart Front Left Window Motor, Door Module |
26 | 30A Smart Front Right Window Motor, Door Module |
27 | 30A Sunroof |
28 | 20A Sony amplifier, 10-channel |
29 | 30A Sony amplifier, 14-channel |
30 | Reserve |
31 | Reserve |
32 | 10A SYNC, GPS Module, Display, RF Radio Receiver |
33 | 20A Radio receiver |
34 | 30A Relay "run / start" |
35 | 5A Airbag and seat belt control module |
36 | 15A Lane Departure Warning Module, Auto High Beam, Electronic Mirrors, Heated Rear Seats |
37 | 20A Heated steering wheel |
38 | 30A Left front window motor, Electric rear window motors |
In the engine compartment
Fuse box rippled with the battery and is covered by a protective cover.
Type 1
Cars manufactured up to 2015.
Photo - example.
Diagram | |
---|---|
№ | Appointment |
1 | Reserve |
2 | Reserve |
3 | 30A Trailer braking system control module |
4 | 30A Wipers, windshield washer |
5 | 50A Anti-lock brake system (ABS) pump |
6 | Reserve |
7 | 30A Rear lifting door with electric drive |
8 | 20A Transparent hatch |
9 | 20A Power socket 2 (rear console) |
16 | Reserve |
17 | 40A 110V AC power socket |
18 | 40A Front blower motor |
19 | 30A Starter |
20 | 20A Power socket 1 (cigarette lighter) |
21 | 20A Power socket 3 (luggage compartment) |
22 | 30A Seat module third row |
23 | 30A Power driver's seat, memory module |
24 | 30A Towed trailer (TT) battery charge relay |
26 | 40A Heated rear window, heated mirrors |
27 | 20A Power circuit (console) |
28 | 30A Climate control seats |
29 | 40A Motor cooling fan 1 high speed mode power supply circuit, motor cooling fan 1 and 2 low speed mode primary fuse |
30 | 40A Engine Cooling Fan 2 High Speed Mode Circuit Fuse |
31 | 25A Secondary fuse for low speed mode of fan 1 and 2 engine cooling |
39 | 40A Electric motor of the additional blower fan |
40 | Reserve |
41 | 30A Heated rear row of seats |
42 | 30A Passenger seat |
43 | 40A ABS valves |
45 | 5A Rain sensor |
46 | Reserve |
47 | Reserve |
48 | Reserve |
49 | Reserve |
50 | 15A Heated Mirrors |
51 | Reserve |
56 | 15A Transmission control module |
57 | 20A LH headlight with high intensity discharge lamp |
58 | 10A generator sensor |
59 | 10A Brake On / Off Switch (BOO) |
60 | 10A Duplicate trailer lights |
61 | 20A Unlock second row seat |
62 | 10A Air conditioner clutch |
63 | 15A Trailer turn signal / stop lamp (TT) |
64 | 15A Rear wipers |
65 | 30A Fuel pump |
67 | 20A Vehicle power supply (VPWR) 2 (elements of the power unit that affect the toxicity of exhaust gases) |
68 | 20A VPWR 4 (ignition coils) |
69 | 20А VPWR 1 (РСМ) |
70 | 10A VPWR 3 (coil), all-wheel drive system module, variable control of the air conditioning compressor (A / C) |
71 | Reserve |
72 | Reserve |
73 | Reserve |
74 | Reserve |
75 | Reserve |
76 | Reserve |
78 | 20A Right headlight with discharge lamps |
79 | 5A Adaptive cruise control system (ACC) |
80 | Reserve |
81 | Reserve |
82 | 15A Rear window washer |
83 | Reserve |
84 | 20A Trailer side lights |
85 | Reserve |
86 | 7.5A Constant power supply of PCM, PCM relay, adsorber ventilation solenoid valve |
87 | 5A Start relay coil |
89 | 5A Front blower relay coil, electric power assisted steering (EPAS) module |
90 | 10A RSM, TSM, ECM (2.0L engine) |
91 | 10A "auxiliary equipment power supply" mode |
92 | 10A ABS module, factory removal and refueling |
93 | 5A Rear blower motor, rear window heater, towed trailer (TT) battery charge relay |
94 | 30A Operation / start of the passenger compartment fuse panel |
95 | Reserve |
96 | Reserve |
97 | Reserve |
For Ford Explorer cigarette lighters and sockets, fuses numbered 9, 20 and 21 at 20A are responsible. | |
Relay | |
10 | Third row rear seat unlock relay |
11 | Heated rear window relay |
12 | Towed trailer battery charge relay |
13 | Starter relay |
14 | Engine Cooling Fan 2 High Speed Mode Relay |
15 | Fuel pump relay |
25 | Not used |
32 | Auxiliary blower motor relay |
33 | Relay 2 low speed fan 1 and 2 engine cooling |
34 | Blower motor relay |
35 | Engine Cooling Fan 1 High Speed Mode Relay, Engine Cooling Fan 1 Low Speed Mode Relays 1 and 2 |
36 | Not used |
37 | Relay for right turn signal / trailer brake light |
38 | Trailer reversing light relay |
44 | Rear window washer relay |
52 | Not used |
53 | Left turn signal / trailer brake light relay |
54 | Not used |
55 | Wiper relay |
66 | Powertrain Control Module (PCM) Relay |
77 | Trailer side light relay |
88 | Start relay |
98 | A / C compressor clutch relay. |
Type 2
Cars manufactured from 2015.
Diagram | |
---|---|
№ | Decoding |
1 | 20A Power supply to the powertrain control module |
2 | 20A Engine Emissions (MIL) |
3 | 20A Air Conditioning Clutch Control Relay Coil, VACC, Active Louver Grille |
4 | 20A Ignition coils |
5 | Reserve |
6 | Reserve |
7 | Reserve |
8 | Reserve |
9 | Reserve |
10 | 15A Heated Mirrors |
12 | 40A Heated rear window |
13 | Reserve |
15 | 20A Horn relay power supply |
16 | 10A Air conditioning clutch relay power supply |
22 | 25A Electric fan relay No. 2 |
23 | Reserve |
24 | Reserve |
25 | Reserve |
26 | 30A Anti-lock brake system valves |
27 | 30A Power supply of the trailer battery charging circuit relay |
28 | Reserve |
30 | 10A Headlight range correction |
31 | 10A Electric power steering |
32 | 10A Anti-lock braking system module |
33 | 10A Powertrain control module (ISPR) |
34 | 10A Blind Spot Monitoring System, Adaptive Cruise Control System, Front View Camera, Rear Camera |
35 | Reserve |
41 | 40A Rear blower motor |
42 | Reserve |
43 | 40A Front blower motor |
44 | 50A Voltage quality module bus |
45 | 40A Electric fan relay No. 1 |
46 | 30A Trailer brake controller |
47 | Reserve |
48 | 50A Bus RP1 body control unit |
49 | Reserve |
50 | 50A Bus RP2 body control unit |
51 | 50A Electric fan relay No. 3 |
52 | 60A Anti-lock brake system pump |
53 | Reserve |
54 | Reserve |
55 | Reserve |
56 | 40A Power Inverter |
57 | Reserve |
58 | Reserve |
59 | Reserve |
60 | 20A Power socket (front pull-out compartment) |
61 | Reserve |
62 | 20A Power socket (instrument panel) |
63 | 30A Fuel pump |
64 | Reserve |
65 | 20A Power outlet (2nd row) (without USB charger) |
66 | Reserve |
67 | 20A Power socket (luggage compartment) |
68 | Reserve |
69 | 30A Power luggage compartment door |
70 | 20A Left and right headlights brakes and direction indicators of the trailer |
71 | Reserve |
72 | 30A Heated and cooled seats |
73 | 30A Driver's seat module, driver's seat drive power supply |
74 | 30A Power supply for power passenger seat |
75 | 30A Front wiper motor |
76 | Reserve |
77 | Reserve |
78 | 30A Relay for power folding seat row 3 |
79 | 30A Starter relay |
80 | Reserve |
81 | 10A Trailer reversing light relay |
82 | 20A Steering column lock |
83 | 10A Brake pedal position switch |
84 | Reserve |
85 | 5A Row 2 USB Charger (if equipped) |
86 | Reserve |
87 | Reserve |
88 | Reserve |
89 | Reserve |
90 | Reserve |
91 | Reserve |
92 | 15A Relay unit multicontour driver's seat |
93 | 10A generator sensor |
94 | 15A Rear window washer relay |
95 | 15A Rear window wiper relay |
96 | 10A Power supply of the relay coil of the powertrain control module |
97 | 5A Rain sensor |
98 | 20A 2nd row seat motors |
99 | 20A Trailer parking light relay |
For cigarette lighters and USB sockets, fuses numbered 60, 62, 65 and 67 at 20A and 85 at 5A are responsible. | |
Relay | |
11 | Relay for fan No. 3 of the electronic cooling system on the right side |
14 | Powertrain control module relay |
17 | Heated rear window and heated mirrors relay |
18 | Rear blower motor relay |
19 | Not used |
20 | Left side cooling fan relay |
21 | Cooling fan series / parallel relay |
29 | Run / Start Relay |
36 | Blower fan relay |
37 | Trailer battery charge circuit relay |
38 | Air conditioning compressor clutch relay |
39 | Horn relay |
40 | Not used |
Related fuse diagrams
Ford Explorer 4 (U251), 2005 - 2011 |
Ford Explorer 1/2, 1990-2005 |
Ford Explorer 3 (U152), 2001 - 2005 |
Ford Edge (U387), 2006 - 2014 |
Ford Mondeo 3, 2000 - 2007 |
Ford Focus 4 (CEW; 2018 - 2024) |
Comments
Be the first to comment. Nobody responded to this post yet.
Add new comment